1. 您好,歡迎光臨萊州聚峰機械有限公司官方網站! 鄭重聲明 購機 售后 聚峰官微

            全國咨詢熱線

            400-879-1999

            您的位置: 首頁 > 新聞資訊 > 行業新聞 >
            混凝土自上料攪拌機清洗要點及操作注意事項?
            來源:http://www.mag2vow.com/ 日期:2021-06-10
            混凝土自上料攪拌機可裝運由攪拌廠生產的混凝土或按配比混合的骨料(砂、石子)、水泥和水,在運輸過程中,不斷對濕料慢慢攪拌,防止混凝土在運輸過程中初凝和離析。混凝土自上料攪拌機由汽車底盤和混凝土攪拌運輸專用裝置組成,其專用機構主要包括取力器、攪拌筒前后支架、減速機、液壓系統、攪拌筒、操縱機構、清洗系統等。
            The concrete self loading mixer can transport the concrete produced by the mixing plant or the aggregate (sand, stone), cement and water mixed according to the proportion. During the transportation, the wet materials are continuously mixed slowly to prevent the initial setting and segregation of the concrete during the transportation. The concrete self loading mixer is composed of automobile chassis and special equipment for concrete mixing and transportation. Its special mechanism mainly includes power take-off, front and rear supports of mixing drum, reducer, hydraulic system, mixing drum, operating mechanism, cleaning system, etc.
            一 清洗要點:
            1. Cleaning points:
            1、自上料攪拌機每次裝料前用水沖洗進料口,使進料口在裝料時保持濕潤;
            1. From the feeding mixer, flush the feeding port with water before each loading to keep the feeding port moist during loading;
            2、在裝料的同時向隨車自帶的清洗用水水箱中注滿水;
            2. At the same time of loading, fill the cleaning water tank with water;
            3、下次裝料前切記放掉混凝土貯罐內的污水;
            3. Remember to discharge the sewage in the concrete storage tank before the next loading;
                          中科自上料攪拌機
            4、每天收工時徹底清洗混凝土貯罐及進出料口周圍,保障不粘有水泥及混凝土結塊;
            4. At the end of each day, the concrete storage tank and the surrounding of the material inlet and outlet shall be thoroughly cleaned to ensure that there is no cement and concrete caking;
            混凝土自上料攪拌機清洗要點及操作注意事項
            Cleaning points and operation precautions of concrete self loading mixer
            5、自上料攪拌機裝料后沖洗進料口,洗凈進料口附近殘留的混凝土;
            5. Flush the inlet after the charging mixer is charged, and clean the residual concrete near the inlet;
            6、到工地卸料后,沖洗出料槽,然后向混凝土貯罐內加清洗用水30-40L;在車輛回程時保持混凝土貯罐正向慢速轉動;
            6. After unloading at the construction site, wash the discharge chute, and then add 30-40l of cleaning water into the concrete storage tank; When the vehicle returns, keep the concrete storage tank moving in a positive and slow direction;
            二 操作注意事項:
            2. Operation precautions:
            1、起動自上料攪拌機之前,應把攪拌筒操作手柄放在“停止”位置;
            1. Before starting the self feeding mixer, put the operating handle of the mixing drum at the "stop" position;
            2、自上料攪拌機起動發動機后,應使攪拌筒在低速下轉動10分鐘左右,使液壓油溫升到20℃以上后方可工作;
            2. After starting the engine of the feeding mixer, the mixing drum should be rotated at a low speed for about 10 minutes to make the hydraulic oil temperature rise to more than 20 ℃;
            3、自上料攪拌機在露天停放時,裝料前應將攪拌筒反轉,將積水和雜物排出,以保障混凝土的質量;
            3. When the self loading mixer is parked in the open air, the mixing drum should be reversed before loading to discharge the water and sundries, so as to ensure the quality of concrete;
            4、自上料攪拌機在運輸混凝土時,要保障滑斗放置牢固,防止因松動造成擺動,在行進中打傷行人或影響其它車輛正常運行帶爬山機的噪聲。
            4. When transporting concrete, the self feeding mixer shall ensure that the sliding bucket is firmly placed to prevent swing caused by looseness, hurting pedestrians or affecting the normal operation of other vehicles, and the noise of mountain climbing machine.